OUTBOARDS
Affordable Marine Service is San Diego’s #1 Outboard Repair Facility!
Powerhead & Lower Unit Rebuilds ~ Tune-Ups ~ Fuel Injection & Carburetors.
Outboard Repairs & Service (100hp+) | Annual (100-300 Hour Service)
When you bring your engine to Affordable Marine for it’s annual service, we service your ENTIRE BOAT!
-
Check Navigational lights
-
Check anchor light (if equipped)
-
Check all console switches for operation
-
Service all batteries
-
Check bilge pumps, bait pump, wash down pumps.
-
Check trim tabs & reservoir
-
Check steering, top off hydraulic steering reservoir
-
Check central box for stiffness
-
Check wires and clamps at fuel tank sending unit, vent and fill
-
Change water separating fuel filter , check contents
-
Check power tilt & trim, fill reservoir
-
Clean power head fuel strainer, check contents
-
Compression Check
-
Ignition Component Check
-
Set idle & wide open throttle timing
-
Synchronize carburetor linkage
-
Check oil pump link rod adjustment (if equipped)
-
Replace or tighten all fuel & oil line clamps
-
Drain and clean water trap on main oil reservoir
-
Adjust carburetor pilot screws
-
Adjust idle
-
Change spark plugs
-
Lube starter drive
-
Check throttle & shift cable adjustment
-
Lube cowl latches, shift rail & linkages
-
Grease tilt & swivel tubes
-
Drain and refill lower unit, pressure/ vacuum check
-
Remove propeller grease prop shaft
-
PARTS: Spark plugs, water separator fuel filter, lower unit lube and disposal fee